Eau Claire, WI · Northwestern Wisconsin Closed now (715) 450-9897
(715) 450-9897

Asphalt Repair and Patching in Osseo

Asphalt Repair and Patching in Osseo, Wisconsin.

Pothole, patch and sinkhole repair in Osseo, cut back to sound material and rebuilt properly.

Get a Free Estimate Call (715) 450-9897

4.7 from 18 Google reviews

About 25 minutes southeast of Eau Claire. Free estimates, and a straight read on whether it needs doing yet.

A Bobcat skid steer beside two saw-cut sections of asphalt on a commercial parking lot, work area coned off while cars stay parked around it.
1,818 People in Osseo
4.7 Google ratingFrom 18 reviews
2-3 yrs Reseal cycleIn Osseo
400°F Crack fillerDirect-fire rubber

What an Asphalt Repair and Patching Job Looks Like in Osseo

The interchange is the story. Travel-stop and fuel surface takes a kind of punishment almost nothing else does: constant heavy vehicles, tight turning circles, fuel and oil on the surface, and no quiet season to repair in. Sealer won't stick to a fuel-contaminated apron, and that has to be dealt with before anything else happens.

Away from the interchange, Tenth Street is the commercial strip and Eighth Street carries the hospital. Those are ordinary lots with ordinary wear, and they get quoted like anywhere else.

Asphalt Repair and Patching specifically in Osseo

Travel-stop surface fails in a distinctive way: rutting where trucks turn on the same radius and break-up at the aprons. Both are full-depth repairs, and both are full-depth work.

The Driveways and Lots in Osseo

Osseo sits where the north and south forks of the Buffalo River meet, in Trempealeau County, and more importantly where three routes converge: US 10, US 53 and Interstate 94. For a village of 1,811 that produces a commercial profile far larger than the population, concentrated around the interchange.

Over 28 percent of Osseo's housing was built in the 1970s, the sharpest single-decade concentration of any town in the service area. About a third predates 1960 and fewer than eighty units have gone up since 2000.

A 1970s drive is now fifty years old. Some were built properly and have been sealed on a cycle; those are straightforward. Others have never been touched, and on those the honest question is whether there's still a base worth building on.

Osseo

We work the whole village rather than a named handful of neighborhoods.

Around Osseo: Buffalo River, Buffalo River State Trail, I-94 interchange.

Standard 48-inch frost depth. Osseo sits on unglaciated ground like Strum, so the subgrade is residual soil rather than the sorted outwash of the Chippewa valley.

From our jobs

Job Photos

Two fresh asphalt patches laid in a worn parking lot, cones still around them
Full-depth patches laid and coned off
A crew member kneeling at a stall line working patch material by hand
Hand work at the stall lines
A fresh full-depth asphalt patch coned off in a commercial lot outside an industrial building with dock doors
A full-depth patch outside the dock doors

All job photos

Filled vs. repaired

The pothole that comes back every spring is being filled rather than repaired. Cold patch is a temporary measure and an honest one when it's sold as that: it's loose material tamped into a hole, with no bond to the sides and nothing done about the failed base underneath. It gets you through a winter. A real repair means cutting a clean square back to material that's still sound, taking out everything soft below it, putting the base back and compacting it in lifts, then laying hot asphalt and rolling it. The patch ends up stronger than what is around it, which is why the failure doesn't come back through the middle of it.

Filled

The quick version

  • Cold patch tamped into the hole as found
  • Ragged edges, so there's nothing to key against
  • Failed base left in place
  • Back within a season, usually wider

Repaired

What we do

  • Saw cut to clean vertical edges, back to sound asphalt
  • Soft material dug out until the bottom is firm
  • Base replaced and compacted in lifts
  • Hot mix laid, rolled, and the joint sealed

Cold patch has its place: it's the right call in February when nothing else can be done. It's the wrong call in July.

What Decides the Price in Osseo

Repairs are priced by area and by how deep the trouble goes, and the depth isn't knowable until it's open. These are the bands most jobs land in.

Single pothole

Up to a few square feet

Measured on site

  • Saw cut, dig out, base, hot mix, compact
  • Cheaper alongside other work

Failed area or apron

Roughly 50 to 300 sq ft

Measured on site

  • The common commercial repair, and the garage apron at home
  • Priced per square foot once the area is measured

Sinkhole or subgrade failure

Depth unknown until opened

Measured on site

  • Often a drainage or utility problem underneath
  • Assessed and quoted before the machine moves

Several repairs on one visit come down substantially per repair, because getting the machine and the crew on site is most of the cost of a small one. If you have three, have them all looked at.

Repair or repave?

Most lots that get deferred don't need repaving.

What we look at before quoting either one.

  • Two or three potholes, the rest of the surface is soundStraightforward patching. Nowhere near needing an overlay.
  • The garage apron has sunk where it meets the concreteCommon and fixable. Usually settlement under the transition, cut out and rebuilt.
  • Cracked into squares in a few areas, sound elsewhereCut those areas out full depth, patch, then seal the whole surface.
  • That squared cracking across most of the lotThe base has gone broadly. Patching it becomes a rolling cost with no end. An overlay or a rebuild is the answer.
  • Water sits in the same spot after every rainGrade or drainage, and it has to be solved before any surface work, or the new surface fails in exactly the same place.

Photos of the worst two areas are usually enough for us to tell you which it is.

How the Work Goes in Osseo

Same method on a driveway apron and on a loading dock approach.

Find the edge of the failure

The visible hole is smaller than the damage. We sound out where the surface is still supported and cut outside that, not around the hole.

Saw cut square, clean vertical faces

A patch keyed against a clean edge stays. A patch feathered against a ragged one fails at the joint, which is why so many patches fail in a ring.

Dig out to something firm

Everything soft comes out. If the bottom is wet, that's a drainage problem and the best patch in the world won't last sitting on water.

Base back in, compacted in lifts

Compacted in layers rather than dumped and rolled once. This is the invisible step that decides whether the repair lasts two years or twenty.

Hot mix, rolled, joint sealed

Laid to the surrounding grade so water still runs where it's supposed to, compacted, and the perimeter joint sealed against the next freeze.

Booking sealcoating and striping through October · Call (715) 450-9897

Questions We Get in Osseo

What Osseo calls us about, answered straight.

More questions answered
Is Osseo far enough south that the drive costs us something?
No. It is about twenty-five minutes down I-94 and we are through here often enough that it is not a special trip. As anywhere at that distance, two or three drives on the same street in one visit costs each of you noticeably less than one on its own.
We're right off the interchange and our lot takes semi traffic. Is that different?
Yes, and Osseo has more of it than a village of 1,800 normally would, because US 10, US 53 and Interstate 94 all meet here. A lot taking loaded trucks fails in specific places rather than evenly: where they turn in, where they stop, and wherever a trailer's landing gear comes down. Those spots need full-depth repair or concrete, not sealer, and the rest of the lot is usually fine. Worth walking the truck route separately from the car parking when we look at it.
How much does pothole repair cost?
Square footage and depth, mostly. A pothole that stops at the surface is a different job from one where the base underneath has gone, and you cannot tell which you have until it is opened. What we can tell you before that: several repairs done on one visit come down substantially per repair, because the trip and the mobilisation are already paid for. The assessment is free.
Why does my patch keep failing?
Almost always because it was filled rather than repaired: no clean cut, no removal of the failed base, and nothing bonding it to the asphalt around it. The failure was underneath and it's still there.
Can you repair a sinkhole in a driveway or lot?
Yes, and quickly. Our newest review is a sinkhole repaired within seven days. A sinkhole means material is being washed out from underneath, usually by drainage or a failed pipe, so the repair includes finding out why.
Is it cheaper to repair the asphalt or repave it?
Repair, until roughly a quarter to a third of the surface has failed. Past that you're patching patches and an overlay becomes better value. The estimate measures how much of your surface has actually failed.
How soon can we drive on a new asphalt patch?
Hot mix takes traffic as soon as it has cooled, usually a few hours. That's the material rather than a schedule: what a specific repair means for your lot is one of the things the estimate works out.

Get a Free Estimate in Osseo

Tell us what it looks like and we'll come measure it. You get a written price before anything starts.

(715) 450-9897
  • Free on driveways and lots anywhere in the service area
  • A photo of the problem helps, and it can go in the message
  • Surfaces that are not ready yet get told so at the estimate

Get an estimate

Send the form and we'll call you back. The estimate is free.

By submitting, you agree to be contacted about your asphalt repair and patching job. Text messages only go out if you checked the box above. We don't sell your info, ever.

Other Work We Do in Osseo

Asphalt Repair and Patching in Nearby Towns

Everything about asphalt repair and patching, including how the work goes and what changes the price